Exposure to airborne microorganisms and endotoxin in a potato processing plant.
Journal Title: Annals of Agricultural and Environmental Medicine - Year 2002, Vol 9, Issue 2
Abstract
Microbiological air sampling was performed in a big potato processing plant located in eastern Poland. Air samples for determination of concentrations of microorganisms, dust and endotoxin were collected at 6 sites in the division producing potato flakes and meal from dried potato pulp and at 2 sites in the division producing potato syrup from imported starch. The concentrations of total airborne microorganisms were within a range of 28.3-93.1 x 10(3) cfu/m(3). Mesophilic bacteria were dominant at all sampling sites, forming 73.1-98.8% of the total count. Among them, distinctly prevailed corynebacteria (irregular Gram-positive rods) that accounted for 54.3-81.1% of the total airborne microflora. The most common were strains of Corynebacterium spp., followed by strains of Arthrobacter spp., Microbacterium spp., and Agromyces ramosus. The latter species, so far not reported from the air of occupational environments, abundantly develops in the parenchyma of potato tubers. Its airborne concentration increased rapidly after peeling of potatoes, and attained maximal values at cutting and blanching (steaming and sulfuration) of potatoes, and at sacking of potato meal. The proportions of Gram-negative bacteria and endospore-forming bacilli were low, respectively 0.6-7.6% and 2.0-8.1% of total count. Fungi constituted 1.2-26.9% of total count. The dominant species was Aspergillus niger that formed 99.8% of total airborne fungi. The values of the respirable fraction of airborne microflora varied between 25.3-73.2%. The concentrations of airborne dust were 1.4-26.6 mg/m(3) in the division producing potato flakes and meal and 114.9-200.5 mg/m(3) at pouring of potato and corn starch for syrup. The concentrations of airborne endotoxin were in the range of 0.011-0.089 microg/m(3) during the initial stages of potato processing (unloading, washing, peeling) and drastically increased after blanching to the extraordinarily high levels of 45.9-1893.9 microg/m(3). At pouring of starch for syrup, the concentrations of airborne endotoxin were much lower, within a range of 0.029-0.156 microg/m(3). In conclusion, the workers of potato processing facilities could be exposed to large concentrations of microorganisms, dust and endotoxin posing a risk of work-related respiratory disease.
Authors and Affiliations
Jacek Dutkiewicz, Ewa Krysińska-Traczyk, Czesława Skórska, Grazyna Cholewa, Jolanta Sitkowska
Keywords
Related Articles
- EP ID EP58750
- DOI -
- Views 137
- Downloads 0
Postural stability disorders in rural patients with lumbar spinal stenosis
Introduction. Hard work in farming may lead to lumbar spinal stenosis, and consequently, to pain. The pain and neurological disorders may lead to disability and postural disorders.Objective. The aim of the presented stud...
Determinant factors of health in rural women in their perimenopausal period
The environment and lifestyle are known to exert an essential influence on the health of rural women in their perimenopausal period.Objective: To assess the determinant factors of health in rural women in their perimenop...
Effects of climatic conditions on the biting density and relative abundance of [i]Simulium damnosum[/i] complex in a rural Nigerian farm settlement
[b]introduction and objective[/b]. The effect of climatic conditions on the biting density and relative abundance of [i]Simulium damnosum[/i] complex at Adani, Nigeria, from August 2010 – January 2011 was investigated....
Viability of Clostridium sporogenes spores after CaO hygienization of meat waste
The occurrence of the pathogenic species [i]C. perfringens[/i] and [i]C. botulinum spores[/i] in animal by-products poses a potential epidemiological hazard. Strong entero- and neurotoxins produced by these bacteria adve...
Small rodents as reservoirs of <em>Cryptosporidium</em> spp. and <em>Giardia</em> spp. in south-western Poland
[i]Cryptosporidium[/i] spp. and [i]Giardia[/i] spp. have been detected in a range of host species, including rodents. The aim of this study was to determine the distribution of these pathogens and recognition of the rese...