Feasibility of preparing human plasminogen by full chromatography from precipitation of Fraction Ⅲ in low temperature ethanol method
Journal Title: Chinese Journal of Blood Transfusion - Year 2024, Vol 37, Issue 11
Abstract
[Objective] To determine the feasibility of preparing plasminogen (Pg) with Fraction Ⅲ precipitation (hereinafter referred to as FⅢ-P) from low-temperature ethanol process by full chromatography (hereinafter referred to as FⅢ-P process). [Methods] The FⅢ-P was diluted with dissolution buffer at different dilution times and stirring time. The potency and antigen concentration of Pg in dissolution sample were detected and the dissolution and clarification conditions were determined. Pre-treatment of loading sample and pre-experiment of affinity chromatography were carried out on the FⅢ-P dissolution sample to judge whether the loading sample had an impact on the chromatography by observing the performance of the affinity chromatography column and to evaluate whether the affinity chromatography could achieve the purpose of purifying Pg by detecting the plasma protein antigen concentration and Pg potency of the samples in the process. Two batches of FⅢ-P process were studied step by step, and the specific activity, steps and total recovery, and the output of Pg per ton of plasma were calculated. The feasibility of preparing Pg by FⅢ-P process was evaluated by comparing with the data of full chromatography process using plasma as raw material (hereinafter referred to as plasma process). [Results] The FⅢ-P was dissolved with 10 times of dissolution buffer, stirred for 1 hour, centrifuged at room temperature of 10 000×g for 15 minutes. The supernatant was first filtered with a screen, then clarified with an 8/0.8 μm filter, and finally filtered with a 0.45/0.2 μm filter and loaded. Pre-test showed that from clarification and filtration to Pg affinity chromatography, the step recovery of activity and antigen was 39.51% and 108.64%, respectively, the antigen concentration of Pg increased by 31.16 times and the activity increased by 11.39 times after affinity chromatography, which reaching the effect of affinity chromatography purification of Pg. The results of 2 batches of step-by-step scale-up FⅢ-P process showed that the total recoveries of antigen and activity from plasma to SP chromatography of FⅢ-P process were (45.76±1.10)% and (24.15±0.59)%, respectively, which had a total loss of about 1/3 of antigen and about 2/3 of activity compared to the plasma process. The Pg specific activity of SP chromatography eluent was (4.68±0.25) U/mg, which was about half of that of plasma process, but meeted the internal standard of > 4 U/mg. The output of Pg antigen per ton of plasma in the FⅢ-P process was 68.73% of that in the plasma process, and the output of Pg activity per ton of plasma in the plasma process was 29.82% of that in the plasma process, which basically achieved the purpose of waste utilization of FⅢ-P. [Conclusion] The technical route of preparing Pg from FⅢ-P by full chromatography is feasible.
Authors and Affiliations
Jin ZHANG, Shenglan YUE, Chen ZHU, Yan PENG, Yanxiang ZHOU, Lianzhen LIN, Kejin CHEN, Lu FENG, Yong HU, Zhijun ZHOU
Keywords
Related Articles
- EP ID EP752557
- DOI 10.13303/j.cjbt.issn.1004-549x.2024.11.013
- Views 9
- Downloads 0
Ambiguous results of the HLA-DPB1 genotyping results: Based on AllType NGS 11-loci sequencing reagent
Objective To statistically analyze the characteristics of ambiguous results of HLA-DPB1 genotyping given by AllType NGS 11-loci sequencing reagent via two next generation sequencing platforms, i. e. Ion Torrent S5 and Il...
Preparation of a novel double polymerized of red blood cell substitute and preliminary observation of its curative effect
Objective To study the red blood cell substitute preparation method of glutaraldehyde(GDA) and Bis(3, 5-dibromosalicyl) fumarate(DBBF) double polymerized, and also observe its curative effect. Methods The affecting facto...
Hemolytic disease of newborn caused by unexpected antibodies: a retrospective study of 287 cases
Objective To observe the distribution of non-ABO-HDN and its clinical relevance, so as to provide reference for clinical diagnosis and treatment. Methods A total of 287 cases of non-ABO-HDN recorded during January 2012 t...
Informationization and development strategy in blood collection and supply institutions in Beijing
[Objective] To investigate and analyze the current status, needs and issues of information system construction in blood collection and supply institutions in Beijing, and to provide strategic suggestions for the further...
Clinical blood dispatching between hospitals in Shijiazhuang
Objective To analyze the blood dispatching of hospitals in Shijiazhuang area, in order to provide reference for blood dispatching policy of hospitals and ensure clinical blood supply. Methods The hospital blood dispatchi...