Lactic Acid Synthesis by Fungus Rhizopus oryzae F-1030 on Growth Media Based on Sulphite Liquors
Journal Title: Lesnoy Zhurnal (Russian Forestry Journal) - Year 2020, Vol 13, Issue 2
Abstract
Lactic acid is an industrially important product with an expanding consumer market. However, lactic acid production and isolation methods used at the present time are not effective enough, lead to the formation of large amounts of polluting waste and their recycling is economically unprofitable. At the same time, a half of the worldʼs lactic acid production is carried out by the microbiological method based on the fermentation of such costly sugarcontaining substrates as sucrose, molasses, treacle, sugar syrup, etc. These sugar-containing substrates usage significantly increases the final product cost. In order to solve the conomic and environmental problems of lactic acid production it is necessary to revise the current raw material source and put cheaper and readily available sources of carbohydrates, such as sulphite liquor formed during sulphite pulping, into the lactic acid production. In turn to enhance the economic efficiency of the Russian pulp and paper production it is necessary to use such paper production by-products as sulphite liquor to the fullest extent possible. Sulphite liquor is a chemical complex of inorganic and organic compounds such as monoand oligosaccharides. The article considers the dependence of the output of lactic acid synthesized on the sulphite liquor medium by the fingus R. oryzae F-1030 on the used method of cultivation. In case of the semicontinuous culture method, the culture liquid was replaced with the similar volume of the sterile growth medium with the fungus biomass saving when the sugars in the medium were depleted. In case of the batch culture method, the synthesized lactic acid was precipitated with calcium hydroxide and the reducing substances recovery in the culture liquid was achieved by adding concentrated sulphite liquor when the sugars in the medium were depleted. The study demonstrates that the largest amount of synthesized lactic acid is obtained when using the semicontinuous method for cultivation of the fingus on the sulphite liquor medium prepared according to the technology recommended in the industry during preparation growth media for yeast cultivation. If it is impossible to carry out a full industrial pre-treatment of sulphite liquor, it is recommended to use the batch culture method for the fungus in order to obtain more synthesized lactic acid.
Authors and Affiliations
L. A. Mingazova, A. V. Kanarsky, E. V. Kryakunova, Z. A. Kanarskaya
Keywords
Related Articles
- EP ID EP683266
- DOI 10.37482/0536-1036-2020-2-146-158
- Views 312
- Downloads 0
Application of Ash-Polymer Mixtures in the Construction of Forest Roads
The construction of forest roads is one of the priority issues of the forest industry. The underdeveloped forest road network does not allow the use of forest resources, which are situated too far from the civil roads be...
Experimental Studies of the Thermal Regime in the Pavement Layers of Long-Distance Forest Roads
Economic and social development of both the country as a whole and its individual regions is impossible without maintaining the required level of development and technical condition of the road network. This also applies...
Determination of the Mathematical Dependence of the Black Liquor Density on the Dry Matter Content (High Yield Softwood Pulp)
A modern evaporator station is an energy-saving production of evaporated liquor with high dry matter content for ensuring the minimum SO2 emissions from the soda recovery boiler. Such stations are equipped with Falling F...
Growth and Productivity of Non-Indigenous Woody Species in the Middle Urals
Climate warming has been recorded over the last decades. The air temperature in Yekaterinburg has been rising since the 1930s. Temperatures dropped sharply in 1940–1949, then rose sharply and fell again, especially in 19...
Biomass and Volume Estimation Models for Bark of Small-Leaved Linden (Tilia cordata Mill.)
The research is aimed at analyzing variability and developing mathematical models for estimating bark biomass and volume, volume of trunk with bark, and bark proportion of small-leaved linden (Tilia cordata Mill.) trees...