Preparation and antibacterial properties of La-doped TiO2 films on 3Y-TZP ceramic surface

Apply

Preparation and antibacterial properties of La-doped TiO2 films on 3Y-TZP ceramic surface

Journal Title: 口腔疾病防治 - Year 2019, Vol 27, Issue 3

Abstract

Objective To prepare the La-doped TiO2 film on the surface of 3Y-TZP ceramics in order to observe its antibacterial properties, providing an experimental basis for the application of antibacterial zirconia ceramics in the clinic.Method A cylindrical 3Y-TZP specimen with a diameter of 20 mm and a height of 3 mm was prepared. The sol-gel method was used to prepare 1% lanthanum (La)-doped TiO2 sol, and the La-TiO2 film-3Y-TZP ceramic was prepared by dip coating on the surface of 3Y-TZP. The TiO2 thin film-3Y-TZP ceramic was prepared by adding no lanthanum nitrate solution in the same way. The surface morphology of 3Y-TZP ceramic specimens (3Y-TZP group), TiO2 thin film-3Y-TZP ceramic specimens (TiO2 film group), and La-TiO2 thin film-3Y-TZP ceramic specimens (La-TiO2 film group) was observed by scanning electron microscopy, and photocatalysis, antibacterial and cytotoxicity experiments were carried out. For the photocatalytic experiment, four specimens were randomly selected from the La-TiO2 film group and TiO2 film group to observe the degradation rate of methylene blue at different time points under sunlight. In the antimicrobial experiment, five specimens were randomly selected from the La-TiO2 film group, TiO2 film group and 3Y-TZP group. The antimicrobial activity of each group was tested using the bacteriostatic circle method, and the bacteriostatic distance of each group was compared. In the cytotoxicity experiment, three samples were randomly selected from the La-TiO2 film group, TiO2 film group and 3Y-TZP group (negative control group), and the extracts were prepared. Here, 0.064% phenol solution were served as the positive control group. Morphological observation of L-929 cells in four groups was performed after 3 d of culture. Cell viability and relative cell proliferation were measured by MTT assay.Results La-TiO2 films with uniform distribution can be prepared on a 3Y-TZP surface by the dipping-drawing method. Photocatalytic experiments showed that the degradation rate of methylene blue in the La-TiO2 film group was (41.2 ± 1.5)% in daylight for 2 hours, which was higher than that in TiO2 film group (36.5 ± 2.4)%. A significant difference was noted between the two groups (t=3.321, P=0.016). The antimicrobial experiment showed that the antimicrobial distance of La-TiO2 group was (0.34 ± 0.08) mm, which was larger than that of TiO2 group (0.12 ± 0.02) mm. No obvious antimicrobial circle was noted in 3Y-TZP group, and the antimicrobial distance of the La-TiO2 film group was larger than that of TiO2 film group (F=63.798, P < 0.001). Cytotoxicity test showed that the relative proliferation rate of cells in La-TiO2 film group was (89.5 ± 1.3)%, and the cytotoxicity rating was grade 1. Significant differences were noted among the four groups (F=68.250, P < 0.001).Conclusion The La-doped TiO2 film can improve its photocatalytic activity and enhance the antibacterial activity of 3Y-TZP without obvious cytotoxicity.

Authors and Affiliations

ZENG Yongfa, FU Yulin, DAI Qun, SHI Lianshui

Keywords

3Y-TZP ceramic ; Zirconia ceramics ; TiO2 ; La ; Photocatalytic activity ; Antibacterial ; Cytotoxicity

EP ID EP662898
DOI 10.12016/j.issn.2096-1456.2019.03.003
Views 152
Downloads 0