Production, Purification and Characterization of Polygalacturonase from Aspergillus niger in Solid State and Submerged Fermentation Using Banana Peels
Journal Title: Journal of Advances in Biology & Biotechnology - Year 2016, Vol 10, Issue 1
Abstract
Aims: Pectinases are extracellular enzymes produced by microorganisms which break down pectic polysaccharides of plant tissues into simpler molecules like galacturonic acids. Polygalacturonase catalyzes hydrolysis of α-1,4-glycosidic linkages in polygalacturonic acid producing D-galacturonate. Polygalacturonases are hydrolytic depolymerases with endo and exo activities that are widely used in food and chemical industries. This present study aimed to isolate fungal strain capable of producing polygalacturonase, compare its production in SSF and SmF, optimize the cultural conditions as well as purify and characterize the enzyme. Study Design: The design adopted to evaluate the influence of cultural conditions on the enzyme production and physicochemical parameters on purified enzyme activity was One-Factor-at-a-Time approach (OFAT). Place and Duration of Study: Department of Microbiology, Faculty of Science, University of Port Harcourt, Nigeria, between November 2014 and December 2015. Methodology: A total of 12 fungal strains were isolated from fresh banana peels. The isolates were screened for polygalacturonase producing ability using conventional methods and the isolate with the highest zone of inhibition was selected for further studies. The production of polygalacturonase by Aspergillus niger in solid state and submerged fermentation using banana peels as carbon source were compared and the best was used for further production studies. The effect of cultural conditions on polygalacturonase production by the fungus was evaluated. The crude enzyme was purified using ammonium sulphate precipitation and gel filtration on Sephadex G100 and effect of some physicochemical parameters on purified enzyme activity was also determined using standard methods. Results: A total of 5 out of 12 fungi isolated from fresh banana peels were found to be pectin degraders. The most efficient isolate was identified as Aspergillus niger based on its colonial, morphological and microscopic examination. Solid state fermentation (SSF) was found to be more suitable (60.20%) for polygalacturonase production by Aspergillus niger compared to the submerged fermentation (SmF) (39.80%). Optimization of process parameters revealed that 48 h of incubation was the optimum for polygalacturonase production in solid state fermentation, while 72 h was observed for submerged fermentation. Supplementation of fructose to the fermentation medium led to increased enzyme production. KNO3 was the best nitrogen source for polygalacturonase production. The enzyme was purified by ammonium sulphate precipitation (75%) and gel filtration on Sephadex G100. The purified polygalacturonase showed a specific activity of 166.67U/mg with 8.59% yield and purification fold of approximately 42. The optimum temperature for polygalacturonase activity was 40°C. The purified enzyme was stable within 20-50°C for 1 h. The enzyme has an optimum pH activity at 5.0 and was stable within the pH range of 4-6. Co2+ strongly stimulated the enzyme activity while Ba2+ showed the highest inhibitory effect on the enzyme activity. Conclusion: This study has revealed an enhanced production of polygalacturonase by A. niger under solid state fermentation using cost effective agricultural waste (banana peels). Thus, the re-utilization of banana peels as substrate for production of the enzyme by the fungus will minimize the pollution problems their presence may pose to the environment. In addition, the results obtained in this study indicated that the polygalacturonase from A. niger could found immense potential application in industrial sectors and biotechnology.
Authors and Affiliations
Francis Sopuruchukwu Ire, Emmanuel Garba Vinking
Keywords
Related Articles
- EP ID EP351708
- DOI 10.9734/JABB/2016/29593
- Views 75
- Downloads 0
Correlating Zinc Phytoaccumulation of Cyperus iria Linn with Soil Chemical Parameters in a Metal Contaminated Soil Amended with Orange Peels
Correlating Zinc phytoaccumulation of Cyperus iria Linn with Soil chemical parameters in a metal contaminated soil amended with orange peels (waste) was investigated at the Center for Ecological Studies, University of Po...
In vitro Rapid Regeneration of Betel Vine (Piper betle L.)
The experiment was conducted on betel vine (Piper betle L.) for in vitro regeneration in Biotechnology Lab. of the Department of Biotechnology, Sher-e-Bangla Agricultural University, Bangladesh from the period of July 20...
Effects of Biochar and Rhizobium Inoculation on Selected Soil Chemical Properties, Shoot Nitrogen and Phosphorus of Groundnut Plants (Arachis hypogaea L.) in Sokoto State, Nigeria
The research was carried out to determine the effects of biochar and rhizobium inoculation on selected soil chemical properties, shoot N and P of groundnut plant. Two factors were used for this experiment; Biochar and rh...
The Effect of Endosulfan on Ovaries of Mus musculus: A Histological Study
Background: Today pesticidal poisoning is an important health issue. The term “pesticides” covers a wide range of substances of differing chemical composition. Although we know these are useful in agricultural sector. Ho...
Progress in HIV-1 Prevention, Control and Treatment: Genetic Manipulation or Pharmacological Blockade of Chemokine Receptor 5?
For Human immunodeficiency virus type 1 (HIV-1) to invade the host cells it requires human cluster of differentiation (CD4) receptor and a chemokine receptor, principally chemokine receptor 5 (CCR5). Although the viral p...