Detection Experimental Analysis of Light Hydrocarbon Pipe with Coating Layer by Magnetostrictive Ultrasonic Guided Wave
Journal Title: 河南科技大学学报（自然科学版） - Year 2018, Vol 39, Issue 6
Abstract
The magnetostrictive senser ( Ms S) ultrasonic guided wave testing system was adopted for on-line detection of light hydrocarbon pipeline with coated layer. The effects of detection frequency and pipe diameters on the positioning accuracy of pipeline detection were studied. At the same time, the effects of epoxy resin with viscoelastic coating layer on guided wave signal were also analyzed by using three pass and elbow as the defect and reference. The pipes with diameter of 114 mm and 80 mm were detected by the 64 k Hz and 32 k Hz probes. The results shows that the detection accuracy of the pipeline is different with different detection frequency. The higher the frequency is, the higher the positioning accuracy is. The diameter of the pipe has important influences on positioning accuracy of the guided wave signal. The positioning accuracy of diameter80 mm pipe with 32 k Hz frequency is 9. 3 cm, which is much higher than the positioning accuracy 17. 6 cm of114 mm of diameter. The viscoelastic coating has strong attenuation of the detection signal. The average attenuation rate is about 1 d B/m.
Authors and Affiliations
Tao GU, Qiang WANG, Dong HU, Yongjun ZHAI
Keywords
Related Articles
- EP ID EP468448
- DOI -
- Views 61
- Downloads 0
Preparation and Microwave Dielectric Properties of Cold Sintering Ceramics Materials
The NaCl, Li2MoO4, Al N-Na Cl and Zn2SiO4-NaCl materials were sintered by cold sintering method.The dielectric properties of cold sintering materials were investigated at microwave frequency ranges.The results show that...
Impedance Matching Technology Based on Radio Frequency Power Amplifier
The input and output impedance of the transistor used in radio frequency (RF) power amplifier was smaller than the standard impedance of the RF system.If they were directly connected, the power was not effectively transm...
Fault Diagnosis of Rolling Bearing by Improved Hilbert-Huang Transform
An improved Hilbert-Huang transform (HHT) time-frequency analysis method was proposed based on complete ensemble empirical mode decomposition with adaptive noise (CEEMDAN) .A set of intrinsic mode function (IMFs) was gai...
Research on Reinforcement Effect of Widening on Existing Bridges
The employment of a new bridge on the widening of the existing bridge had certain reinforcement effect on the existing bridge.With the variation of transverse distribution coefficient before and after the widening of bri...
Evolution of A Nonlocal Planar Convex Curve
For the evolution problem of curve influenced by external forces, the evolution of a new nonlocal planar convex curve was studied. The convexity of the evolution curve was kept, and the area of the region surrounded by t...