Synergistic Effect of Atmospheric Pressure Cold Plasma and Hydrogen Peroxide as an Efficient Approach for the Control of Citrus Postharvest Green Mold
Journal Title: Journal of Agricultural Machinery - Year 2024, Vol 14, Issue 4
Abstract
IntroductionPenicillium Digitatum (PD) and Penicillium italicum diseases pose significant economic challenges to citrus fruit production across the globe. The primary aim of this research is to investigate the synergistic effects of low concentrations of H2O2 solution combined with transient spark discharge plasma on the inactivation of PD. Additionally, assess the chemical and physical properties. Ultimately, this approach can be presented as an eco-friendly solution for rinsing citrus fruits on an industrial scale.Materials and MethodsThe Penicillium digitatum (PD) isolate (ATCC 24692) was obtained from the Tehran Molecular Mycology Laboratory and cultured on Sabouraud Dextrose Agar medium at pH 5.6 and 27°C for 7 days. The initial concentration of spores in the solution was determined using a UV absorption spectrophotometer, set to 0.1 at a wavelength of 420 nm, and the concentration of spores was approximately equivalent to 106 spores per milliliter (Palou et al., 2002). In this study, the plasma reactor had a point-to-plane geometry. The high-voltage needle electrode was placed above a Petri dish filled with a microbial solution combined with H2O2, while the grounded electrode was immersed in the solution. The distance between the tip of the needle electrode and the surface of the solution was 15 mm. Solutions of 0.05%, 0.1% and 0.5%v/v H2O2 (35% soluble in water) were added to the microbial solution before plasma treatment. The final volume of the solution was 5 ml and exposure times were 2.5, 5, 10, and 15 minutes. The reactor was fed with an air flow of 2 l/min. A transient spark discharge was generated, characterized by a discharge voltage of approximately 18 kV, short durations of less than 100 ns, and high current pulses exceeding 1A, with a repetition frequency ranging from 0.5 to 10 kHz. After treatment, H2O2, NO2â¾, and NO3â¾ as the main long-lived species in plasma-activated solution are measured. Also, physical factors such as electrical conductivity and pH were measured. Data Analysis performed using SAS 9.4 software. Results and DiscussionWith increasing plasma treatment time and H2O2 concentration, the log reduction increased across all treatments. The combination of 0.1 and 0.5% H2O2 solution with plasma resulted in complete inactivation of P. digitatum within just 15 minutes. In plasma-treated solutions, regarding chemical properties, the concentrations of H2O2, NO2â¾, and NO3â¾ increased linearly with the treatment time. Furthermore, the electrical conductivity increased linearly, with a notable acceleration in the treated 0.5% H2O2 solution, reaching 373µS cm-1. Additionally, pH value dropped from an initial value of 6.95, using distilled water as a control, to a low of 2.14 for plasma treated with 0.5% H2O2 after 15 min of exposure.ConclusionThe combined treatment was more effective than the isolated use of hydrogen peroxide solution. H2O2 enhances the effectiveness of plsma sterilization without requiring additional power input. Consequently, the synergistic application of atmospheric pressure plasma and H2O2 proved to be a promising method for the inactivation of PD. The findings indicate that reactive oxygen species (ROS) significantly contribute to the inactivation of PD cells, as well as the concentration of H2O2. Finally, the combination of H2O2 solution at 0.1 and 0.5% with cold plasma presents an environmentally friendly method for sanitizing citrus fruits.Acknowledgment This work was supported by the Ferdowsi University of Mashhad [Grant number 48527]. The authors greatly appreciate the technical support from Mazandaran University in Iran, particularly from the Department of Atomic and Molecular Physics.Â
Authors and Affiliations
E. Barzanouni,H. Sadrnia,F. Sohbatzadeh,S. Khodavaisy,
Keywords
Related Articles
- EP ID EP752570
- DOI https://doi.org/10.22067/jam.2023.82325.1165
- Views 12
- Downloads 1
The effect of dropping impact on bruising pomegranate fruit
Introduction: The pomegranate journey from orchard to supermarket is very complex and pomegranates are subjected to the variety of static and dynamic loads that could result in this damage and bruise occurring. Bruise ar...
Numerical Solution of Mass Transfer Process during Drying of Apple Slices Using Pseudospectral Method
Introduction Convective air drying is one of the oldest and most popular drying methods. Designing and controlling the convective air drying needs the mathematical description of the moisture transfer during the drying p...
Comparison of the Effects of No Tillage, Minimum Tillage and Conventional Tillage on Dry Land Wheat Yield in Pebbly Field in Tropical Region
The current study was conducted to compare different tillage methods on wheat yield in pebbly dry land areas done within three years (2006-2008) in north Khouzestan (Baghmalek city) in randomized block design with five t...
Technical and Economic Feasibility of Using Solar Energy to Provide Heat Load to a Poultry House
IntroductionIn the poultry industry, reducing energy consumption is essential for reducing costs. Energy requirements in the poultry industry include heating, cooling, lighting, and power line energy. Identifying factors...
Testing and evaluation of a rototiller with new ridged blades
Introduction Recently, employment of rotary tillers has been expanded in gardens and small farms, especially in the northern of Iran. However using the L-shaped blades in the conventional rotary tillers have some problem...