THE EFFECT OF EXTRACTION CAKE OF OAT GERM ON THE STRUCTURAL AND MECHANICAL PROPERTIES OF RYE-WHEAT DOUGH AND THE QUALITY OF BREAD
Journal Title: Прогресивні техніка та технології харчових виробництв ресторанного господарства і торгівлі - Year 2019, Vol 1, Issue
Abstract
The article presents the results of research regarding the effect of 10–20% of extraction cake of oat germ on the structural and mechanical properties of rye-wheat dough and the quality of finished products. The effect of extraction cake of oat germ on the spreadable and viscoelastic characteristics of rye-wheat dough was studied using dough model systems made from the mixture of medium rye flour and wheat flour of first grade. It has been shown that the adding of the additive contributes to reducing the dough ball running within 90 minutes of fermentation. Using the elastoplastometer of Tolstoy by the method of parallel plane shift, it has been proved that adding of 10–20% of extraction cake of oat germ contributes to increasing of modulus of instantaneous elasticity and rye-wheat dough elasticity by 1,4–2,9 and 1,1–1,5 times, the growth of plastic viscosity of dough is 3,8–6,3 times in comparison with the dough without additive (control sample). The fact that the addition of the additive being studied contributes to increasing of dough effective viscosity both immediately after kneading the dough and after 90 minutes of it’s autolysis, has been shown on the rye-wheat dough model systems, which is most likely due to the high moisture absorbing and water-retaining capacities of non-starch polysaccharides contained in the extraction cake of oat germ. Based on the experimental studies, better gas holding capacity of the dough with the addition of 10–20% of extraction cake of oat germ has been proved, as evidenced by an increase of dough volume during fermentation by 7,3–22,0% compared to the control sample. On the one hand, such changes are associated with the improvement of dough structural and mechanical characteristics, and on the other, with the activation of dough fermentation microflora due to the high content of mono- and disaccharides, amino acids, vitamins and minerals in the extraction cake of oat germ. The positive effect of extraction cake of oat germ on the formation of dough structural and mechanical characteristics is also evidenced by an increase in the compressibility factor of bread crumb by 32,3–61,2%. It has been established that the introduction of extraction cake of oat germ in the interval being studied, increases the specific volume of products by 10,0–25,0%, dimensional stability – by 6,7–15,5%, porosity – by 5,0–11,7%. Thus, it has been shown that the use of 10–20% of extraction cake of oat germ instead of flour contributes to increasing of the viscosity, resilience, elasticity and plasticity of mixed rye-wheat dough, improving its form-holding and gas holding capacities, which allows to obtain products with high structural-mechanical and physicochemical quality indicators.
Authors and Affiliations
Ольга Самохвалова, С. Г. Олійник, Надія Лапицька, Галина Степанькова, Марина Бондаренко
Keywords
Related Articles
- EP ID EP614998
- DOI 10.5281/zenodo.3263741
- Views 97
- Downloads 0
ВПЛИВ ТЕХНОЛОГІЧНИХ ЧИННИКІВ НА КОЛІР РОСЛИННОЇ СИРОВИНИ
Метою роботи є аналіз літературних даних про вплив різноманітних технологічних чинників на колір рослинної сировини під час її переробки. Подано загальну характеристику природних барвників – хлорофілів, каротиноїдів і ре...
SCIENTIFIC SUBSTANTIATION OF ALIMENTARY PROVISION OF HOMEOSTASIS AND MINERAL METABOLISM OF THE HUMAN BODY
The authors analyzed the ways for alimentary provision of homeostasis and mineral metabolism in human body. Chemical elements are analyzed as the sources of homeostasis provision; the ways for essential micronutrients di...
УДОСКОНАЛЕННЯ РЕЦЕПТУРНОГО СКЛАДУ ПОСІЧЕНИХ НАПІВФАБРИКАТІВ ІЗ М’ЯСА ПТИЦІ (НАГЕТСІВ)
Український ринок заморожених напівфабрикатів і готових до вживання виробів продовжує динамічно розвиватися, але є певні проблеми, пов’язані з якістю продукції, що пропонується. Установлено, що у виробництві заморожених...
DEVELOPMENT OF SAUSAGES FROM THE PEKING DUCK MEAT
В технологии мясопродуктов перспективным направлением исследований является использование мяса водоплавающей птицы. Для расширения ассортимента были разработаны рецептуры мясосодержащих полукопченых колбас с мясом пекинс...
INVESTIGATION OF FATTY ACID COMPOSITION OF THERMODURIC MILK-CONTAINING FILLING WITH SESAME SEEDS CONCENTRATE
Due to modern peculiarities of human diet, much attention is paid to the balance of the product’s chemical composition. This has challenged to create the combination of dairy and vegetable products. Therefore, a new form...